Home       Features       Site Map      Français

Arrow
Arrow
Slider

The Accident Chain

Sounds Like...? — The Final Step in Forging the Accident Chain

This is the tale of a PA31 gear-up landing. It starts with an open nose baggage door. But let's go back to the beginning to see how this crew came to do a belly flop and a 1000-foot slide with the sparks flying.

Step One — Design

The first Murphy in the aircraft design is the nose baggage door warning system. The door is equipped with a warning light that will also activate the Master Caution. The door light is activated whenever the nose door is unlatched and the Battery Master switch is ON. However, to activate the master caution light, the system must first be armed. To do that, the nose baggage door must first be latched. If it is not latched when the Battery Master is turned ON, the system is not armed.
Neither light activated during the accident sequence. Although post-slide checks showed both to be functioning normally.

Step Two — Design

The aircraft is equipped with both a landing-gear warning horn and a stall warning horn. Here comes design Murphy number two. Both are solid-tone warnings. The gear warning sounds at 510 +/- 25 hertz; the stall warning at 675 +/- 25 herz. The human ear does not easily discriminate between frequencies this close in range, making it difficult to determine quickly which warning is sounding the alarm — stall or gear? Perhaps one should be a steady tone while the other is an undulating one.
To lessen stress on the open door, the captain had flown the approach at a deliberately low airspeed. When the horn sounded during the landing flare, he assumed it to be the stall warning and he continued the landing.

Step Three — Maintenance

The baggage door closes using a key to turn the lock. Routine maintenance check might have detected the wear, leading to timely replacement.

Step Four — Living with It

On the day prior to the accident, the pilot did not have a key. He used his thumbnail to turn the lock. Tight fit?

Step Five — Writing It Up

There was no record in the aircraft logs that the lock had been reported as unserviceable.
Steps Four and Five go together. If you decide to live with it and don't write it up, it's not going to get fixed, and it's going to turn back and bite you.

Step Six — A Sense of Urgency

As the flaps and gear were retracted after takeoff, the captain noticed the nose baggage door ajar. He elected to make a tight teardrop turn back to land on the reciprocal runway (the winds were calm).
Noise from an open door can be distracting, but flying the aircraft and completing the checklist is vital. Over the past ten years, there have been 53 Canadian incidents involving open doors on all types of aircraft. The vast majority have concluded with uneventful landings. Some, when the pilots got distracted by the noise and sense of urgency, have resulted in gear-up landings. A few have had fatal results.

Step Seven — Cockpit Resource Management

The PA 31 captain decided to reduce approach speed by 10 knots to reduce aerodynamic loading on the door. He instructed the co-pilot to complete the landing checklist, but he concentrated on accurately flying the reduced approach speed. Therefore, he did not fully monitor the co-pilot's pre-landing checks. Evidently, the co-pilot was also distracted by the open door. He missed the Gear Down step in the checklist.

Step Eight — Confirming the Warning

Many checklists or Standard Operating Procedures require that the crew's first step in reacting to a warning be "Confirm," i.e. "Master Caution — Engine Oil Pressure." Check the pressure gauge, and then call for the checklist procedure to be completed.

Perhaps the PA31 pilot expected to hear a stall warning because of his low approach speed, but he did not confirm. He assumed and continued to a belly flop slide down the runway.

Originally Published: ASL 1/1997
Original Article: Sounds Like...? - The Final Step in Forging the Accident Chain

Self-Paced Recency
Aviation Safety Newsletter
Emergency Operations
Smart Pilot Seminars
Features
Drones
General Aviation Safety
AOPA Flight Training
Ask ATS
Winter Flying
Fuel Management
Float Planes
Upset Training
Fit to Fly
ELTs
SAR

Pilot Resources

Ask ATS

Ask ATS

Have questions about ATS? In partnership with NAV CANADA, SmartPilot.ca is getting you answers!

Read More

Weather

Weather

Do you have the proper weather to fly? View local and national forecasts.

Read More

TSB

TSB

The Transportation Safety Board is an independent agency that advances transportation safety by investigating occurrences.

Read More

Interactive

Interactive Materials

Check out SmartPilot's online courses and other interactive learning materials.

Read More

NOTAMs

NOTAMs

Check out the latest NOTAMs from NAV Canada.

Read More

ASI

Air Safety Institute

Browse through ASI's free safety education and research designed to make you a better pilot from home!

Read More

ELTs

ELTs

Learn about the next generation in SAR.

Read More

ASL

Aviation Safety Letter

Articles include aviation safety, safety insight derived from accidents & incidents, safety information.

Read More

SmartPilot proudly works with.

aopa logocopa logoeaa logo

sar logo

We would like to acknowledge the financial support of the Government of Canada for this initiative through the Search and Rescue New Initiative Fund (SAR NIF).