Home       Features       Site Map      Français

Image is not available
Slider

btn videos engbtn articles engbtn courses eng

Birds and Windshields

B737 windshield

All airplane windshields are manufactured to the same airworthiness standards? The windshield on your general aviation (GA) airplane or light helicopter offers protection from more than just rain, snow and bugs? If you believe these statements, then you could be in for a rude surprise.

In the Aviation Safety Letter, Issue 3/96, we discussed the loss of a PA-28 pilot and airplane en route from Brampton to Hamilton, Ontario, in February 1994. The cause of the crash was most likely a gull penetrating the windshield and blinding the pilot. In the Aviation Safety Vortex, Issue 4/95, we described the results of a western grebe striking the windscreen of a Bell 206 helicopter over Kelowna, British Columbia. If it weren't for the fact that the pilot was wearing a helmet with the clear visor down, the story might have ended in a fashion similar to the PA-28 accident. Worldwide, numerous fatal accidents are reported involving civilian and military airplanes that are lost owing to bird strikes on windshields. The reports follow a pattern similar to that of a Cessna 402 in Kenya that struck an eagle over Masai-Mara in 1985. The pilot was killed instantly, and the airplane crashed, killing everyone on board.

GA airplanes and helicopters are not the only aircraft vulnerable to bird-strike windshield damage. The photograph shows the damage caused to a Kenya Airways B737 that struck a European white stork at 10,000 ft. in 1993. The strike destroyed the windshield and penetrated the fuselage, and broken glass seriously injured the captain. The first officer was able to perform an emergency landing, thereby avoiding tragedy.

Closer to home, on November 14, 1996, an Air Ontario DHC-8 made an emergency landing at Ottawa after the windshield was damaged by a bird strike. The photograph tells the story. Data from ICAO member states from 1980 to 1992 describe 25 significant strikes to windshields involving transport airplanes. Of these, 4 resulted in injury to the flight crew and 8 required precautionary landings. Current airworthiness standards for transport category airplanes (over 12,500 lb.) require that windshields and surrounding structures be capable of withstanding a 4-lb. bird strike at cruise speed from sea level to 8000 ft. Concerns have been raised by ICAO members, particularly India, that the standard should be revised, owing to an increasing number of damage reports involving larger birds. Studies conducted by the USAF support the need to raise the standard to 4.5 lb., and recent developments by the Wright Laboratory have led to the use of injection-molded transparencies in some military aircraft that can withstand remarkable impact forces.

Standards for commuter-category airplanes (between 12,500 and 19,000 lb. and/or 10 to 19 passengers) require that the windshield in front of the pilots be able to withstand a 2-lb. bird strike at maximum flap speed, and transport-category helicopters (over 6000 lb.) must be able to withstand a 2.2-lb. bird strike anywhere on the structure, allowing for continued safe flight and landing for category A operations, and safe landing for category B operations.

Now that we know about the airworthiness standards for transport- and commuter-category airplanes, what about the standards for normal-category airplanes (under 12,500 lb. and 9 or fewer passengers) and helicopters (under 6000 lb. and 9 or fewer passengers)? The page here is blank; there are no requirements. The fact is that the windshield on your normal GA airplane or helicopter is only designed to keep out rain, snow and bugs. Knowing that, at 110 kt., the force of a 1-lb. bird (a small gull) striking the windshield of your light airplane can exceed 1200 lb. per square inch, you may wish to read on and learn how to avoid becoming part of our database.

In 1995, 81 incidents reported to Transport Canada involved bird strikes to windshields. Of these reports, 7 involved damage to the windshield structure. As a GA or helicopter pilot, what measures can you take to ensure that you do not become a statistic? First of all, don't fly in the same airspace as the birds. Birds seldom fly above 1500 ft. AGL, so it makes sense to plan your flights to spend as little time as possible at lower altitudes. Also, if you fly routinely in the same area, you might want to do some research to determine where birds such as gulls (the most commonly struck bird) feed and spend the night. You don't want to be flying at low altitudes on the flight paths that gulls use to move between their roosting sites on lakes or rivers and feeding sites such as landfills. You should also avoid flying over freshly plowed or harvested fields, and, during the spring and fall migrations, you definitely want to keep your eyes open for flocks of waterfowl such as Canada geese. These birds will fly at altitudes up to 15,000 ft. ASL, so be wary. Caution is advised when you are flying in areas where there may be strong updrafts, such as the windward side of hills and mountains. Birds of prey and some flocking birds will take advantage of an opportunity to gain free altitude. In particular, don't underestimate the damage that a bird can do to an airplane. Several accident reports from the United States describe GA pilots intentionally flying into bird flocks to see what might happen. They didn't survive to tell the story.

Fly with your landing, strobe and navigation lights on at all times. It can't hurt to make your airplane as visible as possible. Try to keep your speed low whenever it's safe to do so at lower altitudes. The force of a bird strike is determined by the square of your speed multiplied by the mass of the bird, and so the most important factor is your speed. If you see birds, and can safely pull up, do so: birds under threat tend to dive, so don't dive with them. Finally, if your airplane is stabilized on final approach and you experience a bird strike, continue on and land. There are numerous reports of accidents occurring because of an unsuccessful overshoot following an otherwise non-damaging bird strike.

Skylane's shattered windshield

At the airport, you may wish to reconsider your takeoff decision if you see large numbers of birds in the vicinity of the runway. Call ATC, the FSS or the airport operator to request that the birds be dispersed. If you consistently see large numbers of birds in the airport environment, you might want to lobby the airport operator to do a better job of managing its facility. Remember, the operator is in the business to provide a service to pilots and airlines, and is required to operate a safe facility.

If you happen to be unlucky and a bird penetrates your windshield, remember that your primary focus should be on flying the airplane. If you can see it coming, duck your head below the instrument panel, or at least cover your face to protect your eyes from debris. Try to ignore the wind blast, bird remains, noise, and the fact that your headset will likely blow off and you will be unable to see your instrument panel. (If you have trouble with this part, try sticking your head out of your car at highway speeds, then imagine the turmoil at twice that intensity.) Follow correct flying procedures, and find an airport to make an emergency landing. All helicopter pilots should be wearing helmets with the visors down, and those in fixed-wing airplanes may prevent eye injury by wearing good-quality sunglasses. (It may not look cool, but wearing a helmet and visor in a light fixed-wing aircraft isn't such a bad idea.)

Finally, if you are a flight instructor, or are associated with a flying school or club, advise your colleagues or students that bird strikes are a serious matter and deserve to be part of your risk-management program.

Originally Published: ASL 2/1997
Original Article: Birds and Windshields

SmartPilot proudly works with.

aopa logocopa logoeaa logo

sar logo

We would like to acknowledge the financial support of the Government of Canada for this initiative through the Search and Rescue New Initiative Fund (SAR NIF).